施工升降機設備安裝好之后，更重要的是日常的維修保養和監督查看作業，它是保證設備正常工作的關鍵環節。

      1，定時對設備進行安全專項查看。對處于運用階段的施工升降機，相關項目部至少每月發動二次設備安全專項查看。查看各種穩妥、限位是否能正常運作，連接螺栓有無松動，銷軸的固定有無改變，傳動部位有無異響，附墻的連接，鋼絲繩的磨損以及電氣安全防護情況。查看要有記載，對查看中發現的問題應及時整改。節假日后、惡劣天氣后，也應對設備有針對性的查看，試機工作正常后方可運用。

      2，做好施工升降機的保護保養作業。現在的工程往往工期都很緊，參與施工的工人也很多，就會造成施工升降機每天工作十五六個小時， 甚至二十幾個小時，有時施工升降機還連續工作多天，施工升降機正常的保護保養沒辦法展開，增加了安全危機。相關項目部要充分和諧，安排好現場各工種、各班組的施工、交作業和工序銜接，給施工升降機留出一定的保護保養時間。

      3，加強對相關人員的安全教育。要在三級安全教育的基礎上，對與設備有關的人員進行專門的安全教育。

 

      為了降低隱憂應該按照規定操作，施工升降機安全管理：

      1.電梯啟動前，檢查地線、電纜應完整無損，控制開關應在零位，電源接通后，檢查電壓正常，機件無漏電，試驗各限位裝置、梯籠門、圍護門等處的電器聯鎖裝置良好可靠，電器儀表靈敏(min)有效。

      2.施工電梯經過啟動，情況正常，即可進行空車升降試驗，測定各傳動機構和制動器的效能。

      3.電梯在每班初次載重運行時，必須從較低層上升。嚴禁自上而下，當梯籠升離地面1~2米時要停車試驗制動器的可靠性，如發現制動器不正常，經修復后方可運行。

      4.梯籠內乘人或載物時，應使載荷均勻分布，防止偏重，嚴禁超負荷運行。

      5.操作人員應與指揮人員密切配合，根據指揮信號操作，作業前必須鳴聲示意，電梯未切斷電源開關前，操作人員不得離開操作崗位。

      6.梯運行中如發現機械有異常情況，應立即停機檢查，排除故障后方可繼續運行。

      7.電梯在大雨、大霧和六級以上大風時，應停止運行，并將梯籠降到底層，切斷電源。暴風雨后，應對電梯各有關安全裝置進行一次檢查。

      8.電梯運行到上層和下層時，嚴禁以行程限位開關自動停車來代替正常操縱按鈕的使用。

      9.作業后，將梯籠降到底層，各控制開關撥到零位，切斷電源，鎖好電閘箱，閉鎖梯籠門和圍護門。